West Coast British -
Technical Bulletin
190 Airway
Blvd., Livermore, CA. 94550. Phone 925-606-8301/Fax 925-606-8302
Date: May 2, 1995 (Updated
July 7, 2000)
Subject: Tools & Equipment
Vehicle: Discovery V8i NAS from "RA"
Qt. Description
1 License - Insurance holder.
1 Wheel Wrench; 18" breaker bar w/short extension.
1 1-1/6" Socket, for above.
1 Hydraulic Jack, 3-ton.
1 Tyre Pump, foot operated or electric.
1 Tyre Pressure Gauge.
1 Tyre Patch kit for "tubeless" type.
1 Tyre Patch kit for "tube" type.
3 Tyres Irons.
2 Spare wheel/tyre, of same type.
Qt. Tools Required
1 Adjustable wrench (Crescent), 8" & 12".
1 Screwdriver Set; both Standard & Phillips.
1 Magnetic Screwdriver; Standard, for adjusting/replacing points.
1 Wrench Set; American 3/8" to 1".
1 Wrench Set; Metric 9mm to 19mm (for 109V9 & RR).
1 Socket Set; American 5/16" to 1-1/8", 12-point.
1 Socket Set; Metric 9mm to 19mm, 12-point.
1 Socket 2-3/32", Spindle Nuts, w/adaptor to 1/2" drive.
1 Socket, Spark Plug, magnetic type.
1 Ratchet, 3/8" drive.
1 Ratchet, 1/2" drive.
1 6" Extension, 3/8" drive.
1 12" Extension, 3/8" drive.
1 3" Extension, 1/2" drive.
1 "T" Handle, 3/8" drive.
1 Pry-bar Set.
1 Hammer, ballpeen, medium, 1-lbs.
1 Hammer, plastic/rubber combo.
1 Punch/chisel set.
1 Feeler Gauge; .008" to .025".
1 Channel Locks, small & med.
1 Magnet, small.
1 12' Tape measure.
1 Hacksaw w/extra blades.
3 Pliers; Regular, Needlenose, Wirecutters (1-ea),
2 Safety Wire; Electric Wire Pliers (1-ea).
1 Snap-ring pliers, med.
1 Vise grips; small & med.
1 Duct-Tape.
2 3M Elec Tape.
1 10" Flat File, rough & smooth versions.
1 10" Round File, rough & smooth version.
1 Tool Box; to put it all in!
Qt. Supplies
1 1-lbs of grease, hi-temp type.
1 High-Temp Black "loctite" silicone.
2 Castrol Motor Oil.
1 Anti-freeze (gallon).
1 Radiator Water (gallon).
2 Dextron III ATF.
2 80/90w Gear Oil.
2 Casrtol/Girling Brake Fluid.
1 Funnel.
30 Shop Rags.
Qt. Spares
1 ERR4823 Fan Belt.
1 RTC3197 Dist Cap.
1 RTC9929 Ign Rotor.
1 PRC6574 Ign Coil.
8 RN11YCC Spark Plug.
1 ANR1631 Throttle Cable.
1 ESR3117 Fuel Filter. (FRAM G3727)
1 ERR3340 Oil Filter. (FRAM TG16, DG16, PH16)
A/R ESR1445 Air Filter
1 ESR3297 Rad Hose, top.
1 ESR1819 Rad Hose, bottom.
1 BTR4016 By-Pass Hose.
1 BTR216 Heater Hose (94)… AWR2651 Heater Hose (95-on)
1 BTR217 Heater Hose (94).
3' Univ heater hose.
1 FTC2783 Seal, Hub.
2 RTC3429 Bearing, Hub (GBS197).
2 FTC8700 Nut, Spindle (217355).
1 FTC3185 Washer, Spindle.
1 FTC3179 Locktab, Spindle.
2 571752 Gasket, Hub (axleshaft).
1 7316 Gasket, Diff. (or use Hi-Temp Silicone).
1 STC8572 Brake Pad set, Front.
1 STC8569 Brake Pad set, Rear.
1 STC1636 Shock, Rear.
A/R Misc Bulbs & Fuses.
4' 1/4" Fuel Line. & clamps.
1 Wiper Blade,
1 Radiator Sealer.
1 Genuine Workshop Manual A/R.
Qt Equipment
1 Hi-Lift Jack & mount.
1 8000 Warn Winch.
1 Winching Kit.
1 10,000lbs Tow Strap, nylon.
1 10' Tow Chain.
2 Ancra Tie-Down.
1 Work Gloves.
1 Shovel, Axe, Knife.
1 Flashlight w/extra batteries.
A/R Drinking Water.
A/R Drinking water Tablets.
A/R Gas Can, 5-gallon type.
1 Filler Spout, for above.
A/R Filters for Fuel cans to vehicle.
A/R Fuel Cap Lock.
A/R Spare Wheel Lock.
A/R Toolbox Lock.
1 Hi-powered Back-up light.
A/R Replacement Light bulbs.
1 Jumper Cables.
1 Misc Elec Wire & fittings.
1 Misc Hardware (nuts-bolts).
1 Safe for Money & Passport.
1 First-Aid Kit, Large.
1 First-Aid Manual.
1 Fire Extinguisher.
1 Rain Suit.
1 Plastic Tarp.
1 CB Radio (check local laws).
1 Emergency Food kit.
1 Emergency Road Reflector, Tri-angle type.
1 Work Light, plugs into lighter.
1 Map Light.
2 Hold Down Hooks for load space area.
1 Rear Hitch Insert, flat, w/towing ring.
This list of Tools & Equipment was compiled by WCB for a customers taking Land Rovers out of the country. It is suggested that you equip your vehicle in the same manner.
|